Best 9 North Carolina Pulled Pork Sandwich Recipes

CAROLINA PULLED PORK SANDWICHES

Steps:

• Prepare the Carolina Vinegar Sauce: Vigorously whisk together vinegar, ketchup, brown sugar, Worcestershire, crushed red pepper, and mustard in a medium bowl until sugar dissolves. Measure 1/2 cup sauce into a small bowl; reserve for slow cooker. Cover remaining sauce (about 2 cups) in medium bowl; set aside for serving.
• Prepare the Pulled Pork: Pat pork dry with paper towels. Stir together pimenton, brown sugar, salt, mustard, onion powder, celery salt, garlic salt, and pepper in a small bowl; sprinkle all over pork. Heat oil in a large cast-iron skillet or heavy-bottomed pan over high until hot but not smoking. Add pork; cook, turning occasionally, until browned on all sides, about 10 minutes. Transfer pork to a 5- to 6-quart slow cooker. Add beer to skillet; reduce heat to medium, and cook 30 seconds, stirring to scrape up any browned bits from skillet bottom.
• Pour beer mixture and reserved 1/2 cup sauce over pork in slow cooker. Cover and cook until pork easily pulls away from bone using a fork, 5 to 6 hours on HIGH or 8 to 10 hours on LOW. Remove pork from slow cooker, and transfer to a large heatproof bowl; let stand 15 minutes. Remove and discard bone. Shred meat using 2 forks. Add 1 cup of the reserved sauce from medium bowl to meat, and toss to coat. Serve pork on buns with remaining sauce on the side.

SMOKY NORTH CAROLINA PULLED PORK SANDWICH WITH REDS BARBECUE SAUCE, THREE POTATO SALAD AND COLE SLAW

Steps:

• In a bowl mix all the spices together. Save 1 tablespoon of the rub for sauce. Rub the rest of the mixture vigorously into the pork. Wrap the pork and refrigerate for 24 h
• Place vinegar, sugar, jalapeno and dry rub mixture into a medium saucepan over medium hot heat and bring to a boil. Reduce the heat and simmer for 10 minutes. Remove from heat.
• Preparation: Using only one side of the grill, build a fire with 6 to 10 pounds of charcoal. You will control the heat of the fire by restricting the air flow. Add presoaked hickory chips on the charcoal and smoke should develop. Place the pork butt on the opposite side of the grill as the fire and close the lid. Shut down all air flow possible and maintain a temperature of 225 to 250 degrees for 5 1/2 to 6 1/2 hours; or until the internal temperature of the meat reaches 180 degrees--this is the hard part of barbequing. Remove the pork from the grill and wrap it in heavy duty foil. Let it sit covered in foil for 30 minutes. Unwrap the pork and remove the skin and excess fat. Tear the pork into shreds with forks or your fingers. Place the shredded pork in a bowl and toss with the sauce. Pile the pork high on a bun and serve wit
• Wash all the potatoes. Cut the yams into quarters. Wrap the potatoes in foil. Place all the potatoes in the foil in a single layer on the grill and roast for 1/2 hour. Remove the potatoes from the grill and allow to cool. Cut the red, Yukon gold and 1/2 of the yams into 1/2-inch pieces. Take the remaining pound of yams and remove the skin. Blend the skinless yams, mustard, mayonnaise, lemon juice and celery seed until smooth. Fold in the scallions and cut potatoes and season with salt and pepper. Refrigerate for 2 hours before serving.
• Cole Slaw: 1/4 cup cider vinegar 1 tablespoon honey 1 teaspoon salt 1/2 teaspoon chipotle powder 1/2 cup mayonnaise 1 tablespoon French's Dijon mustard 1 1/2 pounds red cabbage, thinly shredded
• Mix vinegar, honey, salt, chipotle powder, mayonnaise and mustard. Add the cabbage. Toss to coat evenly and ref

NORTH CAROLINA PULLED-PORK BARBECUE

Steps:

• Bring vinegar to a boil with sugar, red-pepper flakes, 2 tsp salt, and 1 Tbsp pepper in a small nonreactive saucepan, stirring until sugar has dissolved, then cool. Set aside 2 cups vinegar sauce to serve with sandwiches.
• While sauce cools, score pork skin in a crosshatch pattern with a sharp knife (forming 1-inch diamonds), cutting through skin and fat but not into meat. Pat meat dry and rub all over with 1 Tbsp each of salt and pepper. Let stand at room temperature 1 hour before grilling.
• Prepare grill for indirect-heat cooking over low heat, leaving space in middle for disposable roasting pan.
• When coals have cooled to about 300°F (45 minutes to 1 hour; when most coals will have burned out), put disposable roasting pan on bottom rack of grill between the 2 remaining mounds of coals, then fill pan halfway with water. Add a couple of handfuls of unlit charcoal to each charcoal mound, then put grill rack on so hinges are over coals.
• Oil grill rack, then put pork, skin side up, on rack above roasting pan. Grill pork, with lid ajar (for air, so coals remain lit), basting meat with sauce and turning over every 30 minutes (to maintain a temperature of 250 to 275°F, add a couple of handfuls of coals to each side about every 30 minutes), until fork-tender (a meat fork should insert easily) and an instant-read thermometer inserted 2 inches into center of meat (avoid bone) registers 190°F, 7 to 8 hours total.
• Transfer pork to a cutting board. If skin is not crisp, cut it off with at least 1/4 inch fat attached (cut any large pieces into bite-size ones) and roast, fat side down, in a 4-sided sheet pan in a 350°F oven until crisp, 15 to 20 minutes.
• When meat is cool enough to handle, shred it using 2 forks. Transfer to a bowl.
• Serve pork, cracklings, and coleslaw together on buns. Serve reserved vinegar sauce on the side.

NORTH CAROLINA-STYLE PULLED PORK

Steps:

• Preheat a grill to medium low and prepare for indirect cooking: On a gas grill, preheat the grill, then turn off the center burners. On a charcoal grill, light the coals, then push to the edges of the grill, creating an open space in the middle; put a disposable aluminum drip pan in the middle of the grill under the grates.
• When the grill registers 250˚ F, place the pork on the grill grates over the cooler part. Cover the grill and cook the pork until the skin is crisp, the meat easily falls off the bone and a thermometer inserted into the center of the pork (away from the bone) registers 190˚ F to 200˚ F, 7 to 10 hours (if using charcoal, adjust the air vents and add more coals as needed so the temperature stays around 250˚ F).
• Meanwhile, make the barbecue sauce: Combine 1 cup water, the vinegar, hot sauce, sugar, red pepper flakes, 2 1/2 tablespoons salt and 2 teaspoons black pepper in a pot. Bring to a boil over medium-high heat, stirring occasionally, until the sugar and salt dissolve. Let cool.
• If using a gas grill, turn off the heat and carefully transfer the pork to a cutting board. If using a charcoal grill, do this quickly, as the grease may cause the coals to catch fire. Let the pork rest at least 30 minutes, then pull the meat off the bone with tongs and a large fork; discard the bones and any large pieces of fat. Chop the crispy skin and stir into the meat. Transfer to a bowl and toss with 1 to 2 cups of the barbecue sauce. Serve on buns with the remaining sauce.

NORTH CAROLINA-STYLE PULLED PORK

Steps:

• In a small bowl, mix mild paprika, light brown sugar, hot paprika, celery salt, garlic salt, dry mustard, ground black pepper, onion powder, and salt. Rub spice mixture into the roast on all sides. Wrap in plastic wrap, and refrigerate 8 hours, or overnight.
• Prepare a grill for indirect heat.
• Sprinkle a handful of soaked wood over coals, or place in the smoker box of a gas grill. Place pork butt roast on the grate over a drip pan. Cover grill, and cook pork until pork is tender and shreds easily, about 6 hours. Check hourly, adding fresh coals and hickory chips as necessary to maintain heat and smoke.
• Remove pork from heat and place on a cutting board. Allow the meat to cool approximately 15 minutes, then shred into bite-sized pieces using two forks. This requires patience.
• In a medium bowl, whisk together cider vinegar, water, ketchup, brown sugar, salt, red pepper flakes, black pepper, and white pepper. Continue whisking until brown sugar and salt have dissolved. Place shredded pork and vinegar sauce in a large roasting pan, and stir to coat pork. Serve immediately, or cover and keep warm on the grill for up to one hour until serving.

NORTH CAROLINA PULLED PORK BBQ SANDWICHES

Steps:

• BBQ Sauce:.
• In medium bowl, combine vinegar, brown sugar, red pepper flakes, Worcestershire sauce, salt and hot pepper sauce. Divide sauce into two portions; set aside.
• Pulled Pork:.
• At least 1 hour before grilling, soak wood chips in enough water to cover; drain before using. Rub meat with salt and black pepper. In a charcoal grill with a cover, place preheated coals around a drip pan for medium indirect heat. Add 1/2 inch hot water to drip pan. Sprinkle half of the drained wood chips over the coals. Place meat on grill rack over drip pan. Cover and grill about 4 hours or until meat is very tender. Add more preheated coals (use a hibachi or a metal chimney starter to preheat coals), wood chips and hot water every 1 to 1 1/2 hours. Remove meat from grill; cover with foil and let stand for 20-30 minutes. Using a fork, shred meat into long, thin strands. Pour sauce over shredded meat; toss to coat. Serve on toasted buns. If desired, top meat with coleslaw. Serve remaining sauce on the side.
• * Note: For gas grills, preheat and then turn off any burners directly below where the food will go. The heat circulates inside the grill, so turning the food is not necessary.

NORTH CAROLINA PULLED PORK

Steps:

• 1. If using the rub, combine the mild paprika, brown sugar, hot paprika, celery salt, garlic salt, dry mustard, pepper, onion powder, and salt in a bowl and toss with your fingers to mix. Wearing rubber or plastic gloves if desired, rub the spice mixture onto the pork shoulder on all sides, then cover it with plastic wrap and refrigerate it for at least 3 hours, preferably 8.
• If not using the rub, generously season the pork all over with coarse (kosher or sea) salt and freshly ground black pepper; you can start cooking immediately.
• 2. Set up the grill for indirect grilling and place a drip pan in the center.
• If using a gas grill, place all of the wood chips in the smoker box and preheat the grill to high; when smoke appears, reduce the heat to medium.
• If using a charcoal grill, preheat the grill to medium-low and adjust the vents to obtain a temperature of 300°F.
• 3. When ready to cook, if using charcoal, toss 1 cup of the wood chips on the coals. Place the pork shoulder, fat side up, on the hot grate over the drip pan. Cover the grill and smoke cook the pork shoulder until fall-off-the-bone tender and the internal temperature on an instant-read meat thermometer reaches 195°F, 4 to 6 hours (the cooking time will depend on the size of the pork roast and the heat of the grill). If using charcoal, you'll need to add 10 to 12 fresh coals to each side every hour and toss more wood chips on the fresh coals; add about 1/2 cup per side every time you replenish the coals. With gas, all you need to do is be sure that you start with a full tank of gas. If the pork begins to brown too much, drape a piece of aluminum foil loosely over it or lower the heat.
• 4. Transfer the pork roast to a cutting board, loosely tent it with aluminum foil, and let rest for 15 minutes.
• 5. Wearing heavy-duty rubber gloves if desired, pull off and discard any skin from the meat, then pull the pork into pieces, discarding any bones or fat. Using your fingertips or a fork, pull each piece of pork into shreds 1 to 2 inches long and 1/8 to 1/4 inch wide. This requires time and patience, but a human touch is needed to achieve the perfect texture. If patience isn't one of your virtues, you can finely chop the pork with a cleaver (many respected North Carolina barbecue joints serve chopped 'cue). Transfer the shredded pork to a nonreactive roasting pan. Stir in 1 to 1 1/2 cups of the vinegar sauce, enough to keep the pork moist, then cover the pan with aluminum foil and place it on the grill for up to 30 minutes to keep warm.
• 6. To serve, mound the pulled pork on the hamburger buns and top with coleslaw. Let each person add more vinegar sauce to taste.

NORTH CAROLINA PULLED PORK SANDWICH

Steps:

• 1. Place pork roast in a dutch oven. Pour BBQ sauce and Coke over roast. Cover with a tightly fitting lid. Wrap entire pan with aluminum foil to ensure a tight fit. Cook at 320 degrees for 4-4 1/2hrs. After 4 1/2hrs remove from oven and check to see if meat falls apart easily; if not, raise temp to 350 degrees and return to oven for another 30-40 mintues. Remove from oven and remove roast from juices. Pull meat apart slowly removing visible fat. Shred meat. You can spearate meat at this point if wanted into two groups (this is what I do); in one group add some of the juices that the meat was cooked in for a sweeter pork sandwich; in the other group leave the meat as is and serve with the Lexington-style coleslaw for a true North Carolina BBQ sandwich.
• 2. LEXINGTON-STYLE BBQ SAUCE: Combine the cider vinegar, ketchup, brown sugar, sugar, kosher salt, white pepper, red pepper and black pepper in a medium, nonreactive bowl. Let stand at least 10 minutes, stirring occationally. Can be made up to 1 week ahead and stored in the refigerator.
• 3. NORTH CAROLINA COLESLAW: Combine the coleslaw mix and 3/4 cup of the Lexington-style BBQ sauce in medium bowl. Refrigerate, covered 2 hr or overnight.
• 4. TO ASSEMBLE: To hamburger buns layer pulled pork (piled high)then North Carolina coleslaw. You may add a little more of the Lexington-style BBQ on top for an extra kick if wanted.

CAROLINA STYLE PULLED PORK SANDWICH

Steps:

• The Meat --.
• Place the quartered onions in a crock pot.
• Combine brown sugar, paprika, salt and pepper: rub over the roast.
• Place the roast over the onions in the crock pot.
• Combine the vinegar, Worcestershire Sauce, red pepper flakes, sugar, mustard, garlic salt and cayenne; stir to mix well.
• Drizzle about 1/2 of the vinegar mixture over the roast and cover. Refrigerate the remaining vinegar mixture.
• Cook on low for 8 hours. Drizzle the other half of the vinegar mixture over the roast during the last 1/2 hour of cooking.
• While the meat is cooking, prepare the barbecue sauce. Mix all ingredients except soy sauce, butter and smoke. Simmer, uncovered, on low heat for 30 minutes. Stir in the remaining ingredients and simmer, uncovered, for 10 more minutes. Set aside to cool.
• Remove the meat from the crock pot and allow to rest for at least 15 minutes. (Very important step -- longer is better).
• Remove the onions and chop to a fine consistency.
• Pull apart the meat with a couple of forks. Meat should have a shredded look to it.
• Mix chopped onions and shredded pork along with a little bit of juice from the crock pot to taste. Add sufficient barbecue sauce to the mixture to achieve desired taste. Meat should have distinctive barbecue flavor.
• To serve, spread barbecue sauce on bottom of a hearty bun.
• Put layer of pulled pork on bun. Spread barbecue sauce over meat.
• Add layer of your favorite cole slaw on top of meat. Layer some more barbecue sauce over cole slaw.
• Spread top of bun with more sauce.
• Grab a fist full of napkins, and enjoy.