Best 8 Grilled Stuffed Pork Loin Recipes

GRILLED STUFFED PORK TENDERLOIN

Steps:

• Preheat a grill to medium high and lightly oil the grates. Butterfly the pork: Slice almost in half lengthwise, stopping about 1/2 inch from cutting through; open like a book and flatten with your hands. Cover with plastic wrap and pound to about 1/2 inch thick with the flat side of a meat mallet or a heavy skillet.
• Rub the pork with the grated garlic and season with salt and pepper. Arrange the red peppers on top of the pork in a single layer, then the basil and mozzarella, leaving a 1-inch border on one long side. Roll up from the opposite long side into a tight log and tie with kitchen twine in three or four places. Rub with 1 tablespoon olive oil and season well with salt and pepper.
• Grill the pork, covered and turning occasionally, until a thermometer inserted into the meat (not the filling) registers 145 degrees F, 12 to 14 minutes. Let rest about 5 minutes, then slice.
• Meanwhile, strip the kale leaves from the stems and tear into pieces. Heat the remaining 3 tablespoons olive oil in a large pot or Dutch oven over medium-high heat. Add the kale, smashed garlic and a big pinch each of salt and pepper. Cook, tossing, until the kale is tender, about 5 minutes. Roughly chop the giardiniera and stir into the kale until heated through, 30 seconds to 1 minute. Divide among plates and serve with the pork.

GRILLED PORK LOIN

Steps:

• Heat the grill. Preheat your grill to 350 degrees F for 2-zone cooking (one indirect side of heat, one direct heat side).
• Prep the roast. Trim any excess silverskin. You can leave a small fat cap on the top of the roast. Drizzle the roast with olive oil and season with chicken seasoning.
• Grill the pork loin. Place the seasoned pork loin directly on the grill grates over indirect heat. Cook the roast for 1 hour to 1 hour 30 minutes or until the pork reaches an internal temperature of 145 degrees F.
• Rest, slice, and serve. Remove the pork from the grill and allow to rest for 15 minutes. Slice into 1/4 inch slices and serve.

STUFFED PORK TENDERLOIN

Steps:

• Cook the bacon. Preheat a 9 inch cast iron skillet over medium-high heat. Add the bacon pieces and cook until the fat is rendered and the bacon pieces are crisp. Remove the bacon pieces to a paper towel to drain and leave the bacon fat in the pan.
• Make the balsamic caramlized onions. Add the butter and the sliced red onions to the empty skillet. Cook for about 20 minutes over medium heat, stirring occasionally, until the onions have darkened considerably in color. Reduce the heat to low and stir in the balsamic vinegar. Remove the onions from the pan and set aside.
• Remove the fat from the tenderloin. Place the pork tenderloin on a large cutting board. Remove any excess fat or silverskin from the exterior of the tenderloin.
• Butterfly the pork. Butterfly open the pork tenderloin by using long strokes of your knife along the side of the tenderloin about 1/2 inch above the cutting board. Keep the slices parallel to the cutting board and roll open the tenderloin while slicing.
• Stuff the tenderloin. Spread the softened cream cheese on top of the butterflied tenderloin. Sprinkle with the shredded manchego cheese, caramelized onions, baby spinach leaves, and bacon pieces.
• Fire up the grill. Preheat your grill to Medium-High heat (about 375 degrees F) for two-zone cooking (one indirect heat side of the grill, one direct heat side). You can also cook this in your oven at the same temperature.
• Roll and secure. Starting with the edge of the pork tenderloin that was the inside (before slicing open) begin tightly rolling the tenderloin back up. It's okay if there are a few casualties that fall out the sides while rolling. Tie the roll together with butcher's twine every inch to inch and a half until the roll is nice and bound. Season the pork tenderloin liberally with the Chicken Seasoning.
• Grill the tenderloin. Place the stuffed pork tenderloin directly on the grill grates on the indirect heat side of the grill. Cook for approximately 20-30 minutes or until the internal temperature of the tenderloin is 145 degrees F in the thickest part of the meat. Turn the pork tenderloin every 5 minutes while cooking.
• Rest and serve. Remove the tenderloin from the grill. Allow it to rest at least 5-10 minutes before removing the butcher's twine, slicing the tenderloin into 1 inch thick rounds, and serving.

GRILLED STUFFED PORK TENDERLOIN

Steps:

• Cut a lengthwise slit down the center of each tenderloin to within 1/2 in. of bottom. In a large resealable plastic bag, combine the wine or broth, brown sugar, ketchup, soy sauce, garlic, curry, ginger and pepper; add pork. Seal bag and turn to coat; refrigerate for 2-3 hours. , In a small saucepan, bring water and butter to a boil. Stir in stuffing mix. Remove from the heat; cover and let stand for 5 minutes. Cool., Drain and discard marinade. Open tenderloins so they lie flat; spread stuffing down the center of each. Close tenderloins; tie at 1-1/2-in. intervals with kitchen string., Prepare grill for indirect heat. Moisten a paper towel with cooking oil; using long-handled tongs, lightly coat the grill rack. Grill pork, covered, over indirect medium-hot heat for 25-40 minutes or until a thermometer reads 160°. Let stand for 5 minutes before slicing.

GRILLED STUFFED PORK LOIN

Steps:

• 1. First char peppers. I cooked mine on the grill. Remove charred skin and dice. Crumble cheese.
• 2. I started slicing my loin and rolling it till I had a flat surface. I pounded down any area's that were thicker than others. Place deli ham on top of pork.
• 3. Place Cotija cheese and diced peppers on top.
• 4. Start rolling from one end to make a log. Secure ends shut with toothpicks.
• 5. Lay bacon out on flat surface barely overlapping each other. Lay loin on top of bacon. Pull bacon up and over loin. Using butchers string tie loin up to help hold shape and secure bacon in place.
• 6. Sear top and bottom over coals or direct heat source on grill. Now move to other side of grill with no direct heat. Cook approx. 1 hr at 350°.

STUFFED GRILLED PORK CHOPS

Steps:

• In a plastic container put the salt, sugar, peppercorns, and mustard powder. Add the hot vinegar and swirl to dissolve. Let mixture sit for 5 to 10 minutes to develop flavor. Add ice cubes and shake to melt most of the ice. Add chops and cover with brine. Refrigerate for 2 hours.
• Remove chops from container and rinse. Cut horizontal pockets in each pork chop for stuffing. Combine rest of ingredients, and put into piping bag that is not fitted with a tip. Pipe each chop full with cornbread mixture. Grill the chops on medium high heat for 6 minutes on each side. Turn each chop 45 degrees after 3 minutes to mark.

HERB-STUFFED PORK LOIN

Steps:

• Starting about a third in from 1 side, make a lengthwise slit down the roast to within 1/2 in. of the bottom. Turn roast over and make another lengthwise slit, starting about a third in from the opposite side. Open roast so it lies flat; cover with plastic wrap. Flatten to 3/4-in. thickness; remove plastic wrap., Combine mustard and garlic; rub two-thirds of the mixture over roast. Combine the chives, sage, thyme, rosemary, 3/4 teaspoon pepper and 1/2 teaspoon salt. Sprinkle two-thirds of the herb mixture over roast. Roll up jelly-roll style, starting with a long side; tie several times with kitchen string. Rub oil over roast; sprinkle with remaining salt and pepper., Using long-handled tongs, moisten a paper towel with cooking oil and lightly coat the grill rack. , Prepare grill for indirect heat using a drip pan. Place roast over drip pan and grill, covered, over indirect medium heat or bake, uncovered, at 350° for 1 hour. , Brush remaining mustard mixture over roast; sprinkle with remaining herb mixture. Grill or bake until a thermometer reads 160°, 20-25 minutes longer. Let stand for 10 minutes before slicing.

GRILLED STUFFED PORK LOIN

Steps:

• make the rub by roasting the corriander in a hot skillet for about 3 minutes or until you can smell the corriander. Grind this and the oregano with a mortar and pestle or spice grinder. Add all other rub ingredients and mix well.
• Rinse and dry the pork loin.
• Using a sharp, long knife cut 1/2 inch above the cutting surface as you roll the loin out. You should have a continuous slab of meat once complete.
• Apply a little rub to the surface.
• layer the spinach over the surface.
• add the cheese.
• roll the pork loin and tie with butcher twine.
• Sprinkle the rub over the outside surface and rub it inches.
• Place it on a grill so that it cooks indirectly and is not directly over the coals. If using propane, cook over the burners not lighted.
• If desired, add smoke wood, chips or a foil packet with wood chips.
• Cook until internal temperature of the meat is 160°F.
• Let the roast rest 15 minutes or so before slicing.